Best rated ignition coil wholesale supplier: Diagnosing a Bad Ignition Coil: Ignition coils typically have a long life of operation — over 100,000 miles. However, they can malfunction eventually, causing that dreaded misfire. This issue will probably start out slowly while being hardly noticeable but will become more problematic over time. When a misfire occurs, even for a few seconds, your engine computer management will likely detect the issue and generate a trouble code. At which point the check engine light comes on. With a diagnostic scanner at a garage or auto parts store, you can then see which cylinder is misfiring and proceed from there. Another sign of a misfire can be a rough engine idle. In extreme cases, the vehicle may feel like it’s surging at a high RPM or like it may stall at low speeds. Other signs that you have a bad ignition coil are worsening gas mileage, sluggish acceleration and a backfiring engine, meaning you hear a loud bang as unburned fuel escapes from the exhaust system. Find extra information on ignition coil supplier.
These multiple-coil-pack-systems are much more reliable than the distributors of the past, but individual ignition coils can still fail over time and lead to an engine misfire condition. When a cylinder misfires, that means the fuel inside it is not burning at the correct time or not burning at all. This is also sometimes referred to as a dead cylinder. Prolonged misfiring can lead to larger problems like warped piston rods or corrosion inside the cylinder wall. It can also cause unburned fuel to leak into your exhaust system, which is bad for the environment and worse for your car’s catalytic converters. Once identified, a misfire should be addressed as soon as possible.
To put it simply, the ignition coil is a transformer, which increases the voltage of tens of volts to tens of thousands of volts, but the voltage input to the primary coil is provided by an electronic igniter. The reason why the ignition coil burns out. Ignition coil burnout is mainly caused by the ageing and breakdown of the insulation layer or the damage of the switching transistor. The large gap between the spark plugs will cause the main coil to load, heat, and age quickly. The small gap between the spark plugs will cause the secondary coil to discharge current, heat, and insulation. Fast, the assembled car coil may have a shorter lifespan, such as poor insulation material durability, the large internal resistance of the coil, high heat generation, and low quality of the tertiary tube. The quality of Haiyan car ignition coil/ automotive ignition coil is guaranteed.
The primary winding of an ignition coil will typically contain 150 to 300 turns of wire; the secondary winding will typically contain 15,000 to 30,000 turns of wire, or around 100 times more than the primary winding. The magnetic field is initially created when the vehicle’s electrical system applies approximately 12 volts to the ignition coil’s primary winding. When a spark is required at a spark plug, the ignition system will switch off the current flow to the primary winding, which will cause the magnetic field to collapse. The collapsing magnetic field will induce a voltage into the primary winding in the region of 200 volts; but the voltage induced into the secondary winding will be approximately 100 times greater, around 20,000 volts.
When the electric current is initially switched on, the current flow rapidly increases to its maximum value. Simultaneously, the magnetic field or flux will progressively grow to its maximum strength, and will become stable when the electric current is stable. When the electric current is then switched off, the magnetic field will collapse back in towards the coil of wire. There are two main factors that affect the strength of the magnetic field: Increasing the current being applied to the coil of wire strengthens the magnetic field; The higher number of windings in the coil, the stronger the magnetic field.
Haiyan ignition coil suppliers produce a number of different product series, including car coil, tool cabinets and hardware accessories. The products of Haiyan ignition coil wholesale suppliers have the following advantages: well-chosen materials, reasonable design, stable performance, excellent quality, and affordable price. Such a product is up to customers’ needs for a highly cost-effective product. Haiyan is a ignition coil suppliers and car coil company which have created a number of successful series, and car coil are one of them. Find more information at https://www.hj-auto.com/.
Haiyan car ignition coil suppliers have 200 workers, around 170 work over 4 years, with an independent long-term workflow and productivity, have one department including 30 products technology development and research. Our automotive ignition coil manufacturers cover over 14000 square meters, have been awarded city contracts and keeping promises to units, also we certify ISO9001, and TS16949 for a quality system, truly achieving the quality first, reputation first quality service for our customers at home and abroad. Kindly welcome domestic and overseas patrons to come and guide.